Product ID:POLYURETHANE AEROSOL COLORS
MSDS Date:06/29/2000
FSC:8010
NIIN:01-434-2113
Status Code:A
MSDS Number: CKYPZ

PACIFIC WEST CHEMICAL CORP

337 SUMMIT DR
CORTE MADERA, CA 94925-0183
US

Emergency Phone: 999-999-9999

Info Phone: 415-924-4560

Preparer: HENRY SIMMONS

Cage: 58977

PACIFIC WEST CHEMICAL CORP

183 CORTE MADERA, CA 94925-0183 US

Telephone: 415-924-4560

Cage: 58977

N-BUTYL ACETATE

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 710 MG/M3;150 PPM

ACGIH TLV: 713 MG/M3;150 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

MINERAL SPIRITS

CAS: 64475-85-0

RTECS: PY8240000

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1800 MG/M3;1000 PPM

ISOBUTANE

CAS: 75-28-5

RTECS: TI4300000

N-BUTANE

CAS: 106-97-8

RTECS: EJ4200000

ACGIH TLV: 1900 MG/M3;800 PPM

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC: IRRITATION OF
THE RESPIRATORY TRACT, OR NERVOUS SYSTEM, DEPRESSION- CHARACTERIZED
BY HEADACH, DIZZINESS, NAUSEA, OR POSSIBLE UNCONSCIOUSNESS. SKIN
AND EYE CONTACT: PRIMARY IRRI TATION. PROLONGED OR REPEATED CONTACT
TON SKIN MAY CAUSE DERMATITIS-EXERCISE DUE CARE.

First Aid:VAPORS: REMOVE FROM EXPOSURE AND RESTORE BREATHING, SEEK
MEDICAL ATTENTION. SPLASH: (SKIN) WASH AFFECTED AREA, REMOVE
CONTAMINATED CLOTHING, SEE PHYSICIAN IF ANY IRRITATION PERSITS.
SPLASH: (EYES) FLU SH IMMEDIATELY WITH WATER FOR 15 MINUTES AND
TAKE TO A PHYSICIAN.

Flash Point Method:TCC
Flash Point:=-26.C, -14.8F
Lower Limits:.7%
Upper Limits:12.8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT WATER
SPRAY MAY BE USED TO COOL WATER CONTAINERS EXPOSED TO HEAT OR FIRE
TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:CLOSED CONTANERS MAY EXPLODE DUE TO BUILD
UP OF PRESSUER FROM EXTREME HEAT OF FIRE. AEROSOL FIRE IS EXTREMELY
FLAMMABLE.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION: FLAMES,
SPARKS, STATIC ELETRICITY AND ELECTRICAL. VENTILATE AREA AND SOAK
UP WITH INERT ABSORBENT USING NON-SPARKING TOOLS.

Handling and Storage Precautions:DO NOT STORE ABOVE 120 DEG F. DO NOT
STORE OR USE NEAR HEAT, SPARKS, OR FLAME.
Other Precautions:DO NOT GET IN EYES. DO NOT BREATHE VAPORS. AVOID SKIN
CONTACT. DO NOT TAKE INTERNALLY. SMOKING WHILE USING THIS PRODUCT
MUST BE STRICTLY PROHIBITED. IN ADDITION TO ALL OTHER HAZARDS AND
PRECAUTIONS- D UST FROM SANDING THE DRY PAINT FILMS SHOULD BE
TREATED AS A NUISANCE DUST WITH A TLV OF 10MG/CUBIC M ETER.

Respiratory Protection:OUTDOORS: WE RECOMMENDED AN APPROVED PARTICULATE
FILTER TO REMOVE ANY AIRBORNE OVERSPRAY IN RESTRICTED AREAS WITH
POOR VENTILATION AND CLOSE TO THE T.L.V. INDOORS: A NIOSH APPROVED
RESPIRATOR WITH ORG ANIC VAPOR CARTRIDGE IS RECOMMENDED.
Ventilation:ALL APPLICATION AREAS SHOULD BE ADEQUATELY VENTILATED IN
ORDER TO KEEP THE INGREDIENTS IN SECTION II BELOW THEIR EXPOSURE
LIMITS.
Protective Gloves:IMPERVIOUS GLOVES ARE RECOMMENDED TO PREVENT SKIN
OCNTACT.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS IS RECOMMENDED TO
PREVENT EYE CONTACT
Other Protective Equipment:EYE WASH FOUNTAIN AND SAFETY SHOWER.
IMPERVIOUS APRON TO PREVENT SKIN CONTAC IS RECOMMENDED.
Work Hygienic Practices:AVOID PROLONGED OR REPEATED CONTACT. DO NOT
BREATHE VAPORS. WASH CONTAMINATED CLOTHING PRIOR TO REUSE.
Supplemental Safety and Health

Boiling Pt:=-23.3C, -10.F
Vapor Pres:65PSI@70F
Vapor Density:>AIR
Spec Gravity:.7
VOC Pounds/Gallon:358
VOC Grams/Liter:2.99
Evaporation Rate & Reference:>N-BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID/ SOLVENT BASE ODOR
Percent Volatiles by Volume:48

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CO, CO2, HCL, TRACES OF PHOSGENE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. O NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.